When the Dragonforce Vehicle is taking off after the Rangers have agreed that Blake and Hunter will pilot it up to Lothor's ship, the Green Samurai Ranger is seated in the cockpit rather than Blake and Hunter.
After several of the monsters are thrown into the Abyss, moments later the same ones are still fighting the Rangers.
Lothor apparantly managed to get in Ninja Ops using a 'DNA handprint' identical to his brother's. However, even identical twins have different fingerprints, and it is hard to imagine the fact that Cam would leave his father's handprint in the computer after his father was transformed into a guinea pig.
The Storm Megazord spent well over a minute in Lightning Mode.
Hunter says that Zurgane would never have left the ship without his sword. In fact Zurgane hadn't left the ship without his sword, the problem was that it seemed he'd returned to the ship without it.
In the Hurricane Megazord Cam is in Super Samurai Mode, when he plays the Riff Blaster he's in his regular ranger mode, but in the next shot he's back in Super Samurai Mode
Power Sphere #9 was skipped when Power Sphere's 1-10 were summoned. To add to that Power Spheres # 11, 12, and 14 were never shown to be summoned but are still present for the Mammoth Megazord.
When Cam plays the Lightning Riff Blaster and it comes out of the Megazord's head, do you notice that it's the Wind Ranger's Ninja Sword that is in it, not his Saber. I say this because if the Thunder Rangers use it, it has the Thunder Staff, the Wind Rangers it was the Ninja Sword, and for Cam his Samurai Saber.
If the Dolphin Zord is not part of the Hurricane Megazord, then why is Tori in the cockpit?
INCORRECTLY REGARDED AS A GOOF: Even though in "Beauty and the Beach" Shane's fear is revealed to be spider's, the nightmare collar shows the deepest darkest fears which would be Shane being disrespected by his broher.
In the final shot of the Rangers inside the Hurricane Megazord's cockpit as they celebrate the destruction of Eyezak, Cam is in Super Samauri Mode, when he was shown only seconds earlier in normal mode. He shouldn't have needed SSM as he was only sat in the cockpit.
One of the clips of "past defeats" Lothor is viewing features Dustin using his Lion Hammer on Shimazu, but such a battle never occurred in the series.
Both Toxipod and Supertoxipod can be seen in the alternate dimension, despite the fact they are the same being.
In original broadcast order, the lack of an introduction of Turtle Mace makes for a major continuity headache.
In this episode the Rangers say "Power Down" and go into their ninja form, not civillian form.
When Dustin, Tori and Blake were fighting the Wolfblades, you could ovbviously see that the footage was from Sentai--in the background there was Japanese signs.
Why does Vexacus have the centipede symbol on him from the start if he's not part of Lothor's army? Clearly, they both knew of each other beforehand, but a connection would have been nice.
Dustin used sunless tanning lotion, so why does he have tan lines around his eyes from wearing sunglasses?
After being thrown by Vexacus, you could see Shane's morpher is on the wrong (his right) arm for a few seconds.
From when the Lightning Megazord first transformed up to when it got back to normal, it was over 2 minutes.